畫冊印刷常常會出現油墨粉化，那我們要怎樣避免這樣的現象呢？下面就讓濟南印刷廠和大家一起來了解學習一下吧。
Ink powdering often occurs in album printing. How can we avoid this phenomenon? Now let Jinan Printing Factory and everyone to learn about it.
想要避免畫冊印刷油墨粉化，就要進行原因分析：
In order to avoid the powdering of printing ink in picture albums, the reasons should be analyzed first.
(1)畫冊印刷時，由于油墨的粘著力太小，再加上紙張表面比較光滑，導致墨層和紙張表面不能很好的貼合，進一步導致墨層從紙面上擦落。
(1) In album printing, because the adhesion of ink is too small and the surface of paper is relatively smooth, the ink layer and the surface of paper can not fit well, further leading to the ink layer from the paper surface scratch.
(2)由于油墨太稀薄，連結料很容易被紙張吸收，大量的連結料滲透到紙內，促使油墨中連結料與顏料成分離狀態，造成顏料顆粒浮于紙面上，顏料失去連結料的粘附，其連結程度降低，從而不能良好地附著在紙面，引起脫落。
(2) Because the ink is too thin, the binder is easily absorbed by the paper, and a large number of binders penetrate into the paper, which makes the binder and pigment components separate from each other, resulting in the floatation of the pigment particles on the paper surface, the loss of the binder adhesion of the pigments, and the reduction of the degree of the binder, which can not be well adhered to the paper surface, resulting in shedding.
(3)使用的油墨乳化嚴重，不但降低粘度，干燥速度，增大滲透量，更重要的是乳化了的油墨結膜后不能與紙面很好的結合，附著力較差，而且膜層堅固程度極差，輕微的擦動就會使膜層破裂而脫落。
(3) The use of ink emulsification is serious, not only reduce the viscosity, drying speed, increase permeability, more importantly, the emulsified ink conjunctiva can not be well combined with the paper surface, adhesion is poor, and the film is very weak, slight rubbing will make the film break and fall off.
(4)銅版紙是在原紙上涂布涂料而成，涂料和原紙都有較強的吸收性，而且紙質較厚，能吸收大量的連結料，加之涂層表面光滑，孔隙極細，不可能將顏料一起吸入，起到了過濾層的作用，導致顏料顆粒浮于紙面，因缺少連結料的包裹而脫落。
(4) Copper plate paper is coated with paint on the base paper. The coatings and the base paper have strong absorbability, and the paper is thicker, which can absorb a large number of binders. In addition, the coating surface is smooth and the pore is very fine. It is impossible to inhale the pigments together. It plays a role of filter layer, which causes the pigments particles to float on the paper surface and fall off due to the lack of linking materials.
以上是造成畫冊印刷油墨粉化的可能原因，現在我們找到原因了，下一步就好分析辦法了。
These are the possible reasons for the powdering of printing ink in picture albums. Now that we have found the reasons, the next step is to analyze the method.
